Lion Air pilots battled confusing malfunctions before crash

Bloomberg

The Lion Air pilots whose plane nosedived into the Java Sea in October, killing all those aboard, were battling multiple malfunctions almost as soon as the doomed flight began, according to a trove of new data released by Indonesian investigators.
They faced a cacophony of warnings that started seconds after takeoff and continued
for the remaining 11 minutes before the crash.
The alerts included a so-called stick shaker — a loud device that makes a thumping noise and vibrates the control column to warn pilots they’re in danger of losing lift on the wings — and instruments that registered different readings for the captain and copilot, according to data presented to a panel of lawmakers in Jakarta.
The data also showed that in the final seconds, as they struggled to pull the Boeing Co. 737 Max 8 out of a dive that was being commanded by the plane’s flight computers, the pilots were pulling back on the control column with a force
of as much as 100 pounds of pressure.
However, the data indicated that the plane was controllable — the pilots had kept it under control for about 10 minutes before the final plunge — and records from the previous flight of the same jet showed
another set of pilots had an identical set of failures and landed safely.
“There are so many questions it’s sort of hard to put in one short statement,” said Roger Cox, a retired investigator with the US National Transportation Safety Board and a former
airline pilot.
“I would be very interested in knowing why one crew was able to cope with this stick shaker and trim anomaly, and why the next crew could not,” Cox said. “And I’d want to know why Lion Air could not or would not repair the problem.”
Lion Air Flight 610 crashed on October 29, killing all 189 people aboard. The jet was knifing through the air at about 500 miles (805 kilometres) per hour, or more, in its final seconds as it neared the water, according to the plane’s crash-proof flight recorder.
In a statement, Boeing deferred comment to the Indonesian National Transportation Safety Committee. The manufacturer has sent two updates to operators of the Max jet since the crash, which include reminders that there are existing emergency procedures for such situations. “We are confident in the safety of the 737 Max. Safety remains our top priority and is a core value for everyone at Boeing,” the company said.
Preliminary findings may be released on November 28,
Soerjanto Tjahjono, the Transportation Safety Committee’s chairman, told lawmakers in Jakarta.
In the past week, Boeing has stepped up its response by pushing back on suggestions that the company could have better alerted its customers to the jet’s new anti-stall feature. The three largest US pilot unions and Lion Air’s operations director, Zwingly Silalahi, have expressed concern over what they said was a lack of information.
As was previously revealed by investigators, the plane’s angle-of-attack sensor on the captain’s side was providing dramatically different readings than the
same device feeding the copilot’s instruments.
Angle of attack registers whether the plane’s nose is pointed above or below the oncoming air flow.
A reading showing the nose is too high could signal a dangerous stall and the captain’s sensor was indicating more than 20 degrees higher than its counterpart. The stick shaker was activated on the captain’s side of the plane, but not the copilot’s, according to the data.
Also as a result of the erroneous sensor reading, a new safety feature on the Max called the Maneuvering Characteristics Augmentation System, which automatically tries to lower the plane’s nose to prevent stalls, apparently was activated. The plane’s trim system, which makes adjustments that pitch the aircraft’s nose up or down, moved more than 30 times during the flight.